experimental study of sawdust in fine aggregate in concrete

EXPERIMENTAL STUDY ON PARTIAL REPLACEMENT OF FINE ...

Experimental Study on Partial Replacement of Fine Aggregate with Quarry Dust and Red Soil in Concrete Dhanalakshmi.S1, Mangaiyarkarasi.A2, Bavani.S3, Anusha.D4 Kumar.A5 1UG Student, Department of Civil Engineering, V.R.S. College of Engineering & Technology, Villupuram [email protected]

Effect of Replacement of Fine and Coarse Aggregate by ...

All the specimens were prepared at 1:1.5:3 with 0.50 w/c ratio and tested at 7, 14, 21, 28 and 56 days curing ages. It is observed from experimental analysis that the workability of fresh normal concrete is 7% and 10% greater than recycled aggregates concrete blended with 10% RHA and only recycled aggregates concrete without RHA respectively.

EXPERIMENTAL STUDY ON EFFECT OF SILICA SAND AS …

plastic waste partially replaced as fine aggregate in concrete. 2.3 FLEXURAL STRENGTH TEST For each mix two prisms of size 500mm long, 100mm breadth, and 100mm depth were cast to S.No Concrete type Experimental Value × 104 (N/mm2) Theoretical Value × 104 (N/mm2) 1 Reference concrete 2.25 2.23 2 10% of plastic waste replaced concrete 2.01 2.23

Vol. 5, Issue 4, April 2016 Experimental Study of Coarse ...

EXPERIMENTAL STUDY ON STRENGTH OF CONCRETE BY PARTIAL REPLACEMENT OF FINE AGGREGATE WITH SAW DUST R.chitra 1, Hemapriya 2 Assistant Professor 1,2,Department of Civil Engineering 1,2 BIST, BIHER, Bharath University [email protected] Abstract -This paper represents the results of the

Experimental Evaluation of Strength Properties of Concrete ...

110 Int. J. Struct. & Civil Engg. Res. 2014 Kumar S et al., 2014 EXPERIMENTAL STUDY ON REPLACEMENT OF FINE AGGREGATE BY QUARRY DUST IN CONCRETE Vijay P Gowda1, Dinesh1, Kiran muchandi1, Avinash1 and Kumar S1* The reduction in the sources of natural sand and the requirement for reduction in the cost of

Experimental study on the mechanical properties of ...

Sawdust Ash (SDA) generated from rice mills is usually delivered to landfills for disposal. Using of sawdust ash in concrete is an interesting possibility for economy on waste disposal sites and conservation of natural resources .This paper examines the possibility of using sawdust ash as replacement in fine aggregate for a new concrete.

Experimental Study on Recycled Concrete Aggregates with ...

The study was an experimental study on hollow concrete blocks in a partial replacement of fine aggregate with sawdust in different proportion. The amount and kind of cement was constant, but the quantity of sawdust, aggregate and water was varied. The study was conducted in different steps.

EXPERIMENTAL STUDY ON REPLACEMENT OF FINE …

Wei wu et al.(2010),This study investigated the mechanical properties of high strength concrete incorporating copper slag as a fine aggregate and concluded that less than 40% copper slag as sand substitution can achieve a high strength concrete. The results indicated that the strength of the concrete …

ECO-FRIENDLY CONCRETE

Tomas U. Ganiron/, "Effect of Sawdust as Fine Aggregate in Concrete Mixture for Building Construction", 2014, International Journal of Advanced Science and Technology Vol.63, pp 73-82. Turgut P, "Cement Composite with Limestone Dust and Different Grades of WoodSawdust". 2007, Building and the Environment, 42, 3801 – 3807.

Partial Replacement Of Sand With Sawdust In Concrete

Experimental Study on Palm Kernel Shells as Coarse Aggregates in Concrete Daniel Yaw Osei, Emmanuel Nana Jackson Abstract— This paper reports on experimental investigations on the effects of replacing crushed granite in concrete with palm kernel shells on the strength, density and workability of concrete.

EXPERIMENTAL INVESTIGATION ON LIGHT WEIGHT …

In this experimental study an attempt will be made to find the effect of partial replacement of Fine aggregate by Quarry Dust and Cement by Fly ash. The innovative use of Quarry Dust in concrete formulations as a fine aggregate replacement in the

(PDF) EXPERIMENTAL INVESTIGATION ON THE FEASIBILITY OF ...

IJAETMAS is a team of Scientist and academician in field of engineering technology, management science and applied science. It is an international online journal which emphasis on advancement and ...

Experimental Research of Saw Dust as Partial Replacement ...

The aim of this study, therefore, is to examine the use of locally available construction materials such as sawdust as substitutes for fine aggregate in concrete. Concrete is a construction material which consists of the mixture of fine, coarse aggregate, cement which proportionally mixed with certain percentage of water.

Use of Saw Dust as Fine Aggregate in Concrete Mixture

An experiment investigation was carried out to evaluate the compressive strength of concrete cured at normal curing condition for 3 days, 7 days and 28 days. Sawdust concrete made with 3%, 5%, 7%, 8%,10% replacement with fine aggregate. Thermocol concrete made by replacing coarse aggregates with thermocol balls.

EXPERIMENTAL STUDY ON EFFECT OF SILICA SAND AS …

The study was an experimental study on hollow concrete blocks in a partial replacement of fine aggregate with sawdust in different proportion. The amount and kind of cement was constant, but the quantity of sawdust, aggregate and water was varied. The study was conducted in different steps.

Experimental study on mortar as partial replacement using ...

Elizabeth Joseph/, "Partial replacement of fine aggregates with sawdust for concrete", International Journal for technological research in engineering Vol.3, (2016). [3] Daniel Yaw Osei, Emmanuel Nana Jackson/, "Compressive strength of concrete using sawdust as aggregate…

Experimental Study on Suitability of Sea Sand as Fine ...

EXPERIMENTAL STUDY ON CONCRETE BY PARTIAL REPLACEMENT OF RICE HUSK ASH FOR CEMENT, COPPER SLAG WITH FINE AGGREGATE AND CERAMIC TILE WASTE WITH COARSE AGGREGATE Gomathi.S1, Thenmozhi.S2 Ph.D, Chinnasamy.M3 M.E., M.B.A 1M.E-Construction Engineering and Management Student, Sree Sastha Institute of Engineering and Technology, Chennai.

(PDF) REPLACEMENT OF FINE AGGREGATE WITH SAWDUST

Nov 03, 2020· This revealed Doka sawdust as more suitable than Afara sawdust for partial replacement of fine aggregate in concrete. Saravanan et al., (2020) conducted an experimental study on the physical and mechanical behaviour and its properties of concrete which …

EXPERIMENTAL STUDY ON CONCRETE BY PARTIAL …

AN EXPERIMENTAL STUDY ON STRENGTH PARAMETRES OF CONCRETE WITH REPLACMENT OF FINE AGGREGATE BY ROBO SAND T.Dilip Kumar *1 & G.Kalyan 2 *1PG Student, Department of civil Engg, ASRCE, Tanuku 2Assistant Professor, Department of civil Engg, ASRCE, Tanuku. DOI: 10.5281/zenodo.1199005 ABSTRACT Concrete is the most …

Journals Of Replacement Of Sand By Quarry Dust In Concrete Pdf

Abstract. This experimental study aimed to develop an acceptable concrete mixture with sawdust particles as substitute to fine aggregate that can be used for building construction particularly in residential class concrete slab and analyze the effect of sawdust concrete mixture in terms of adhesion of aggregates, thermal insulation, workability and surface quality.

STUDY ON PARTIAL REPLACEMENT OF PLASTIC WASTE …

All the specimens were prepared at 1:1.5:3 with 0.50 w/c ratio and tested at 7, 14, 21, 28 and 56 days curing ages. It is observed from experimental analysis that the workability of fresh normal concrete is 7% and 10% greater than recycled aggregates concrete blended with 10% RHA and only recycled aggregates concrete without RHA respectively.

The effect of recycled PET bottles on the fracture ...

Saw Dust As Fine Aggregate In Concrete. replacement course aggregate and fine aggregate Concrete mixtures were prepared, saw dust, discarded tires, e-waste, glass, bagasse ash, stone dust and ceramic Get Price And Support Online; saw dust as fine aggregate in concrete effect of sawdust as fine aggregate in experimental study on partial replacement of fine aggregate …

AN EXPERIMENTAL STUDY ON STRENGTH PARAMETRES OF …

Experimental Study on Partial Replacement of Fine Aggregate with Quarry Dust and Red Soil in Concrete Dhanalakshmi.S1, Mangaiyarkarasi.A2, Bavani.S3, Anusha.D4 Kumar.A5 1UG Student, Department of Civil Engineering, V.R.S. College of Engineering & Technology, Villupuram [email protected]

Table 3 from THE USE OF SAWDUST ASH AS FINE AGGREGATE ...

Conventional concrete which is produced by the mixture of cement, coarse aggregates, fine aggregates, and water is less environmental friendly due to calcination and mining of sand in river and sea. Polymer concrete is thus promoted where the cement and fine aggregates are replaced partially within itself. In this study, mechanical properties such

Experimental Research of Saw Dust as Partial Replacement ...

Compressive Strength of Concrete Using Sawdust as Aggregate Daniel Yaw Osei, Emmanuel Nana Jackson Abstract—This paper reports on experimental investigations on the effect of replacing sand with sawdust on the properties of concrete. A concrete mix of 1:2:4 was used as control while sawdust was used to replace 25%, 50%, 75% and of sand ...

(PDF) Performance of Pre-Wetted Sawdust as a source of ...

Jul 17, 2020· Experimental study on mortar as partial replacement using sawdust powder and GGBS. ... River sand has been the most popular choice for the fine aggregate components of concrete in the construction. The over use of river sand has led to environmental concerns. ... The sawdust concrete wall has better thermal resistance than ordinary wall and 5% ...

Experimental Study on Suitability of Sea Sand as Fine ...

1 day ago· In this study, recycled polyethylene terephthalate (PET) bottles are shredded in different sizes and added to the polymer concrete composition to inve…

EXPERIMENTAL STUDY ON STRENGTH OF CONCRETE BY …

fine aggregates with sawdust. Various features like compressive strength, water absorption and density were studied at various replacement percentages. To assess the performance of timbercrete blocks at multiple replacement percentages and experimental study was conducted. Hence, blocks of dimensions

Effect of Replacement of Fine and Coarse Aggregate by ...

Key Words: Compressive strength, Concrete, Sawdust, Light weight concrete, Fine Aggregate. 1. INTRODUCTION Concrete is a mixture of cement, fine and coarse aggregates and water, which are mixed in a specific proportion to get a particular strength. Both cement and water react together chemically to form a paste, which binds the aggregate

Experimental Study on Palm Kernel Shells as Coarse ...

(PDF) Use of Quarry Dust to Replace Sand in Concrete An. This experimental study presents the variation in the strength of concrete when replacing sand by quarry dust from 0% to in steps of 10%. M20 and M25 grades of concrete were taken for study keeping a constant slump of 60mm. The compressive

Experimental Study on Use of Quarry Dust and Fly Ash with ...

The various materials used in this experiment are Cement, Fine aggregate, Coarse aggregate, Saw dust ash (SDA), Chemical admixture, Polypropylene Fibre (PP) and Water Cement The cement used in this experimental work was Dalmia 53 Grade Ordinary Portland Cement having specific gravity-3.15 and normal consistency- 30%.

Experimental Study on Partial Replacement of Fine ...

Experimental Research of Saw Dust as Partial Replacement for Fine Aggregate in Production .. 2 partial replacement for fine aggregate will contribute more to the quality and strength of the sandcrete blocks. [15] States thatsawdust is one of the natural fiber that is used as filler. Sawdusts are collection of fine particle of hard and soft woods.

Experimental Study on Palm Kernel Shells as Coarse ...

Experimental Study on Suitability of Sea Sand as Fine Aggregate for Concrete. Prabin Kumar. K. Anna University Department of Civil Engineering. Udaya School of Engineering Vellamodi, Kanyakumari Dsct. Abstract:- Concrete is the most popular building material in the world.

Experimental Study on Concrete Compressive Strength …

Experimental Study on Concrete Compressive Strength made by Sawdust as a Partial Replacement of Sand ... sawdust in concrete as a new construction material simultaneously by protecting our environment. ... tests including gradation and sand equivalent tests for fine aggregates, Los Angeles and aggregates crushing value ...

Sawdust as an Alternative Material for Sand in Concrete ...

fine aggregates with sawdust. Various features like compressive strength, water absorption and density were studied at various replacement percentages. To assess the performance of timbercrete blocks at multiple replacement percentages and experimental study was conducted. Hence, blocks of dimensions

Experimental Study on Concrete Compressive Strength …

Experimental Research of Saw Dust as Partial Replacement for Fine Aggregate in Production .. 2 partial replacement for fine aggregate will contribute more to the quality and strength of the sandcrete blocks. [15] States thatsawdust is one of the natural fiber that is used as filler. Sawdusts are collection of fine particle of hard and soft woods.

Experimental Evaluation of Strength Properties of Concrete ...

Experimental Study on Concrete Compressive Strength made by Sawdust as a Partial Replacement of Sand ... sawdust in concrete as a new construction material simultaneously by protecting our environment. ... tests including gradation and sand equivalent tests for fine aggregates, Los Angeles and aggregates crushing value ...

Study on Strength of High Performance Concrete by Partial ...

Experimental method was used by the researchers for it examined and investigated the possibility of using sawdust as a fine aggregate in concrete mixture with both mixtures categorized as Class A mix with the proportions of 1:2:4 of cement, a fine aggregate, and a coarse aggregate respectively.

(PDF) IRJET- Use of Saw Dust as Fine Aggregate in Concrete ...

This study focuses on the experimental investigation of using saw-dust as a partial replacement of sand in the properties of concrete mix. Saw dust also known as wood dust is a by-product or waste...

Experimental Study on Recycled Concrete Aggregates with ...

Experimental Study on Palm Kernel Shells as Coarse Aggregates in Concrete Daniel Yaw Osei, Emmanuel Nana Jackson Abstract— This paper reports on experimental investigations on the effects of replacing crushed granite in concrete with palm kernel shells on the strength, density and workability of concrete.